jeep UNIVERSAL SERIES SERLVICE MANUAL H H 1555 SERVICE DIHGNlZ Sl S Continued SYMPTOMS PROBABLE REM EDY Generator continued Fails To Charge Open Charging Circuit Corznxrect Sticking Brushes Repair or Replace Dirty or Burned Commutator Clean Cornmutator Grounded Commutator Replace Open Circuit in Field A V Replace Weak Soldering on Armature 4 Repair Grounded Wiring 4 4 Repair Defective Regulator i Replace Regulator Too High Charging Ratca Regulator Improperly Adjusted Adjust or Replace Short in Armature 4 i Rleplace Grounded Field to regulator W ire Correct Shorted Cell in Battery A Replace Battery Startingi Motor Slow Starter Speed Discharged Battery or Sliorted Cell i Recharge or Repair Ground Strap Engine to Frame Clean Terminals and Tighten Loose or Dirty Terminals c 4 Clean and Tighten Dirty Commutator A c V Clean with No 0 0 Sandpaper Worn Out Brushes Install New Brushes Weak Brush Spring Tension A A A A Replace Worn Bearings 4 A r Replace Burned Starter Switch Contacts i Replace Switch Will Not Turn Engine Open Circuit at Starter A Corree1 Solenoid Open or Stuck A A Replace Solenoid Starter Switch Defective A A Replace Switch Starter Drive Broken or Stuck A Repair or Replace Battery Discharged A l A AA Recharge Battery Distribuntor Hard Starting Distributor Points Burned or Pitted A A Clean Points or Replace Adjust Breaker Arm Stuck on Pivot Pin Clean and Lubricate Breaker Arm Spring Weak A Replace Points Improperly Adjusted A A Adjust Spark Plug Points Improperly Set Adjust Spark Plug Wire Terminals in Distributor Cap Corroded A e Clean Loose Terminals A Check Circuit Loose or Dirty Terminals on Ground 1Strap Engine to Frame AAAr uA Clean and Tighten Condenser Faulty A A e Replace Improper Ignition Timingr A A Set lTirni ri g Lights Burn Dim Loose or Dirty Terminals r Clean and Tighten Leak in Wires A A AA A Cheecick Entire Circuit for Broken Insulation Poor Switch Contact sr A A Install New Switch Poor Ground Connection A A Clean and Tighten Aim Headlamp Beams A A AA Use Aiming Chart 221